Rammstein Air RS-3001-EHS-30KW Electric Paint Booth Heater

Brand:
iDEAL
SKU:
RS-3001-EHS-30KW
Condition:
New

Price is subject to change if the product is on backorder. Contact us at 800-562-4791 for availability.

Total Price:
$16,198.80 $13,999.00
(You save $2,199.80)
Shipping Calculated at Checkout
Shipping Calculated at Checkout

Price is subject to change if the product is on backorder. Contact us at 800-562-4791 for availability.

Rammstein Air RS-3001-EHS-30KW Electric Paint Booth Heater

The RS-3001 electric Air Make Up unit is a combination electric heater and waterborne paint drying system.  The system operates by pulling air from the booth through the blower and the heater delivering the heated air back into the booth via gable mounted air nozzles.  The RS-3001 has four easily selected user: Pre-Heat, Spray, Heat Flash-Off, Bake.

The RS-3001 electric paint booth heater is less expensive to install and operate than our RS-1001 gas fired paint booth heater.  A typical 30KW electric paint booth heater costs on average $2.00 per cycle (using $0.12 / KWH) which is significantly less than a similar gas fired paint booth heater while providing 45F – 50F degree temperature increase in approximately 50 minutes.  This increase allows the booth to reach the desired flash off temperature for waterborne finishes and to reach a temperature high enough to bake the finish coat.

The RS-3001 can be used on our Side Down Draft, Semi Down Draft and the Cross Flow paint booths.

Features

  • Vertical / Side Discharge configuration
  • White Powder coat finish
  • ETL Listed Control Panel
  • Single point connection
  • Exhaust VFD fused and wired
  • Hour meter
  • Control panel messages
  • Time display shows cycle time and elapsed time
  • Truly variable air flow
  • Interlock status indicator lights
  • 30′ Umbilical card
  • Easy-to-use controls

Specifications

Specifications  
AMU Heater Model RS-3001
Fuel Electric
BTUH NA
Gas Train NA
CFM NA
Intake Motor NA
Exhaust VFD NA
Blower Motor 2HP / 208VAC or 230VAC / 3Phase / 6.3A
Heating Element 30KW / 208VAC or 230VAC / 3 Phase / 85A
Temperature Rise Approx. 30˚F in 10 Minutes / 50˚F in 50 Minutes
Ship Weight 560 lbs
PSB Model Usage Cross Flow, Side Down & Semi Down Draft

We can configure a system with single phase electrical and other voltages.  Please contact us for a quote.

TUXEDO DISTRIBUTORS LIMITED WARRANTY

Structural Warranty:

The following parts and structural components carry a five year warranty:

Columns, Arms, Uprights, Swivel Pins

Legs, Carriages, Overhead Beam

Tracks, Cross Rails, Top Rail Beam

Limited One-Year Warranty:

Tuxedo Distributors, LLC (Tuxedo) offers a limited one-year warranty to the original purchaser of Lifts and Wheel Service equipment in the United States and Canada. Tuxedo will replace, without charge, any part found defective in materials orworkmanship under normal use, for a period of one year after purchase. The purchaser is responsible for all shipping charges. This warranty does not apply to equipment that has been improperly installed or altered or that has not beenoperated or maintained according to specifications.

Other Limitations:

This warranty does not cover:

1. Parts needed for normal maintenance

2. Wear parts, including but not limited to cables, slider blocks, chains, rubber pads and pulleys

3. Replacement of lift and tire changer cylinders after the first 30 days. A seal kit and installation instructions will be sent for repairs thereafter.

4. On-site labor

Upon receipt, the customer must visually inspect the equipment for any potential freight damage before signing clear on the shipping receipt. Freight damage is not considered a warranty issue and therefore must be noted for any potential recovery with the shipping company.

The customer is required to notify Tuxedo of any missing parts within 72 hours. Timely notification must be received to becovered under warranty.

Tuxedo will replace any defective part under warranty at no charge as soon as such parts become available from the manufacturer. No guarantee is given as to the immediate availability of replacement parts.

Tuxedo reserves the right to make improvements and/or design changes to its lifts without any obligation to previously sold, assembled or fabricated equipment.

There is no other express warranty on the Tuxedo lifts and this warranty is exclusive of and in lieu of all other warranties,expressed or implied, including all warranties of merchantability and fitness for a particular purpose.

To the fullest extent allowed by law, Tuxedo shall not be liable for loss of use, cost of cover, lost profits, inconvenience,lost time, commercial loss or other incidental or consequential damages.

This Limited Warranty is granted to the original purchaser only and is not transferable or assignable.

Some states do not allow exclusion or limitation of consequential damages or how long an implied warranty lasts, so the above limitations and exclusions may not apply. This warranty gives you specific legal rights and you may have other rights, which may vary from state to state.

 

Frequently Bought Together

Please choose options for all selected products

  • Choose Options